A list of mine explosions appears at the end of this story.
CHARLESTON, W.Va. -- Late on the morning of March 9, 1976, a huge explosion ripped through the Scotia Mine in Letcher County, Ky. Fifteen workers died. Two days later, 11 more were killed in a second blast.Federal investigators traced the first fatal explosion to sparks from a battery-powered locomotive being used in a fresh-air intake tunnel in the underground mine.Air in the tunnel should have been free of explosive methane and coal dust. But various ventilation violations by Scotia Coal Co. allowed methane to build up in the tunnel.And use of the battery-powered locomotive, with gears, air brakes and a compressor that could have easily created sparks, was perfectly legal -- then and now.In most parts of an underground coal mine, operators must use only explosion proof, or "permissible" electrical equipment. Such special gear is not required in fresh-air intake tunnels, which are supposed to be free of explosive gases and dust.But in the three decades since Scotia, at least seven other major coal-mining explosions were caused by the use in intake airways of electrical equipment not designed to prohibit sparks, according to federal government reports.Over the last 34 years, nearly half of the deaths from mine explosions occurred in intake airways, the reports show. Some were ignited by miners smoking, or by sparks from rock hitting rock in a roof fall. But in most cases, those intake tunnel explosions were traced to the perfectly legal use of regular electrical vehicles, circuit breakers, belt controls, cables and other gear, instead of specially designed explosion-proof equipment.The issue is a "considerable problem," according to Tom Dubaniewicz, an electrical engineer who has researched intake airway explosions for the National Institute for Occupational Safety and Health.Dubaniewicz wrote two papers for NIOSH about the problem, one in September 2007 and another in January 2009. Both papers, widely available to the mining industry and its regulators, called for reforms in the type of electrical equipment allowed in intake airways in underground coal mines."There really is no law applicable to sparking equipment in the intakes," Dubaniewicz said in an interview last week.
And so far, despite the 34-year record of deadly explosions, no one has proposed any changes in federal law or U.S. Mine Safety and Health Administration regulations to address the problem.Asked last week if the agency was aware of the NIOSH research, thought it revealed a serious problem, or planned any action in response, MSHA officials issued a two-sentence statement."We will take a look at the findings of the report, and see where they're at with their recommendations," the statement said. "Then we will meet with NIOSH officials to discuss where we go from here."Investigators have yet to begin sifting through evidence underground to pinpoint the ignition source in the April 5 explosion that killed 29 miners at Massey Energy's Upper Big Branch Mine in Raleigh County. It will be many months before conclusions are drawn or reports made public about the worst U.S. coal-mining disaster in 40 years.
A preliminary MSHA report, ordered by President Barack Obama, blamed the blast on an ignition of methane that was probably made far worse by a buildup of highly explosive coal dust.Investigators say they are starting out focused on two theories about possible ignition points: One is in the "gob," or the unsealed, mined-our area where the roof caves in behind Upper Big Branch's longwall mining machine; The other is in a "development section," where continuous mining machines prepare for the longwall to work. One possibility, investigators said, is that the ignition could have occurred in an intake airway in that development section.
But regardless of where the Upper Big Branch explosion was ignited, mine safety experts last week said the two reports Dubaniewicz prepared for NIOSH offered stark evidence of another area where mine safety rules have not kept up with clearly known problems that lead to large numbers of deaths.Celeste Monforton, a former MSHA staffer who teaches public health and workplace safety at George Washington University, recalled that after the Sago Mine disaster in 2006 regulators began looking at previous accident reports and NIOSH research that clearly showed lightning strikes and weak mine seals could combine to create a major disaster.And in the case of the intake airway explosions, Monforton noted, state and federal regulators wrote reports of each incident, but apparently never connected the dots and updated their safety standards."It sends these shivers down my spine," Monforton said as she read Dubaniewicz's papers last week. "It's very disturbing."
Several coal industry officials did not respond to requests for comment for this story.Davitt McAteer, a longtime mine safety advocate who ran MSHA during the Clinton administration, said the need for explosion-proof equipment only tells part of the story.McAteer said proper design and operation of underground mine ventilation systems should keep explosive gases and coal dust out of intake airways. In each of the instances cited by Dubaniewicz, problems started when mine operators did not design good ventilation systems or violated their ventilation plans, allowing methane or coal dust to build up in those intake tunnels.At Scotia, for example, the company had redirected fresh air meant for the area where the first explosion occurred into other parts of the mine. Federal investigators cited the company for "inadequate ventilation" and for not conducting pre-shift methane checks of the area where the ignition occurred."We ought to only have permissible equipment in the intakes, but the rest of the story is the negligence of the operators and the fact that proper ventilation could have prevented these," McAteer said. "But because this is an industry that neglects redundant safety systems, we need to add more redundancies."Dubaniewicz began his research while reading the MSHA report on the series of explosions in September 2001 that killed 13 miners at the Jim Walter Resources No. 5 Mine in Brookwood, Ala.The initial explosion, which seriously injured one miner, was later traced to arcing of a battery charging system that was damaged by a roof fall. The second blast, which claimed the lives of 12 miners headed to rescue their injured co-worker, was linked to a traffic light system for underground vehicles."I was kind of surprised to see that the ignition locations for both explosions were in the intakes," Dubaniewicz said.After its own investigation of the Brookwood disaster, the United Mine Workers union recommended tougher rules for insulation of electrical wiring and for "increased safety" requirements for some installations, such as battery charging stations."Obviously, you cannot take equipment out of the intake airways," said Dennis O'Dell, the UMW's safety director. "But there are things that can be done."Reach Ken Ward Jr. at email@example.com or 304-348-1702.Mine explosions
Here is a list of mine explosions that occurred in intake airways and were blamed on sparks from electrical equipment that was not explosion proof:March 9 and 11, 1976 -- A total of 26 miners were killed in two explosions at the Scotia Mine in Letcher County, Ky. The first of the fatal blasts, which killed 15 miners, was blamed on sparks from a battery-powered locomotive used in an intake air tunnel.Nov. 7, 1980 -- Five miners died in an explosion at Westmoreland Coal's Ferrell No. 17 Mine near Uneeda, W.Va. Investigators trace the ignition to a locomotive used in an intake airway.June 21, 1983 -- Seven miners are killed in an explosion at Clinchfield Coal Co.'s McClure No. 1 Mine at McClure, Va. The ignition was believed to have been caused by sparks from one of the following: A battery-powered mantrip, a circuit breaker, a dinner hole light connection, an electrical cable plug, or a cable for a conveyor belt feeder.July 4, 1983 -- One miner is killed at Helen Mining Co.'s Homer City, Pa., Mine. Investigators blame arcing on mine vehicle controls.Feb. 16, 1984 -- Three miners die in an explosion at Pennsylvania Mine Corp.'s Greenwich Collieries No. 1 Mine in Indiana County, Pa. Arcing of a battery powered locomotive is blamed.Dec. 26, 1987 -- One miner dies in a methane and coal dust explosion at Double R Coal's No. 1 Mine in Duty, Va. Investigators blame two power centers, a battery charging cable and a scoop vehicle.Sept. 13, 1989 -- Ten miners died at Pyro Mining Co.'s Pyro No. 9 Slope William Station Mine at Wheatcroft, Ky. Investigators could not pinpoint whether the ignition occurred at the mine face or in the intake airway, but among the possible sources was a wire in the intake.Sept. 23, 2001 -- Thirteen miners die in a series of explosions at the Jim Walter Resources No. 5 Mine in Brookwood, Ala. The two major explosions were linked to electrical equipment in the intake tunnels.Sources: National Institute for Occupational Safety and Health, U.S. Mine Safety and Health Administration